Product ID:XE-8402A 383 BROWN TYPE II
MSDS Date:10/11/1989
FSC:8010
NIIN:01-160-6745
Kit Part:Y
MSDS Number: BHNFX

NILES CHEMICAL PAINT COMPANY

225 FORT STREET
NILES, MI 49120
US

Emergency Phone: 219-236-5856 (24 HOURS)

Info Phone: 616-683-3377 (INFORMATION)

Preparer: MIKE LICHATOWICH

Cage: 02388

NILES CHEMICAL PAINT

307 NILES, MI 49120 US

Telephone: 616-683-3377/219-236-5856

Cage: 02388

POLYESTER RESIN

Fraction By Weight: 13%

METHYL ISOBUTYL KETONE (SARA III)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 9%

OSHA PEL 100 PPM/75 STEL

ACGIH TLV: 50 PPM/75 STEL; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

N-BUTYL ACETATE (SARA III)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 9%

OSHA PEL 150 PPM/200 STEL

ACGIH TLV: 150 PPM/200STEL;9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 9%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PM ACETATE

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: 6%

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 6%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CHROMIUM (III) OXIDE

CAS: 1308-38-9

RTECS: GB6475000

Fraction By Weight: 5%

OSHA PEL 0.5 MG/M3 (CR)

ACGIH TLV: 0.5 MG/M3 (CR); 8990

VOC. ORGANIC CMPD 4.56 LB/GAL LESS WATER & NPRS* (NK) G/L

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HISTOLOGIC FIBROSIS OF LUNGS,
INCOHERENCE, CORNEAL VACUOLIZATION, ANOREXIA. TAR-GET ORGANS: CNS,
LUNGS, EYES, SKIN, RESPIRATORY SYS, GI TRACT, BLOOD, LIVER,
KIDNEYS.ALSO SEE BELOW
Explanation of Carcinogenicity:NOT LISTED
Effects of Overexposure:EYE: SEVERE IRRI, LACRIMATION, RED, BLURRED
VISION. SKIN: RED & IRRI, DEFATTING OF SKIN, DERMATITIS. BREATH:
NASAL & RESPIRATORY IRRI, CNS DEPRESS (DIZZ, DROWS,WEAK, FATIGUE,
CONF) NAUSEA, HEAD, VERTI GO, UNCONSC, ASPHYX. INGES:
GASTROINTESIRRI, ABDOMINAL PAIN, NAUSEA, VOMITING AND DIARRHEA

First Aid:INHAL: REMOVE TO FRESH AIR AT ONCE. IF BREATH STOPPED, CPR,
GET MED ATTN IMMD. SKIN: IMMED FLUSH W/PLENTY OF WTR. REMOVE
CONTAM CLOTHES & FLUSH SKIN W/WTR. GETMED ATTN. LAUNDER CLOTHES &
SHOES BEFORE REUSE. EYE: IMMED FLUSH LG AMTS OF WTR15 MIN, LIFTING
LIDS. GET MED ATTN IMMED. CONTACT LENS SHOULD NOT BE WORN.
INGESDRINK 1/2 GLASSES WATER. DO NOT INDUCE VOMIT. GET MED
ATTN/POISON CC IMMEDIATELY

Flash Point Method:TCC
Flash Point:20 F/-6 C
Lower Limits:1.0
Upper Limits:10
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:SELF CONTAINED BREATHING APPARATUS W/FULL
FACEPIECE OPERATED POSITIVE PRESSURE & FULL PROT CLOTHES. WTR TO
COOL CLOSED CONTAIN PREVENT PRESSURE BUILDUP/EXPLOS
Unusual Fire/Explosion Hazard:KEEP CONT TIGHTLY CLOSED. VAPORS HEAVIER
THAN AIR, MAY TRAVEL ALONG GROUND TO IGNITE SOURCE. ISOLATE FROM
HEAT, ETC. OVEREXP TO DECOMP MAY CAUSE HEALTH HAZARDS

Spill Release Procedures:ELIM ALL IGNITION SOURCES. MIN BREATHING OF
VAPORSAVOID SKIN CONTACT. ABSORB W/INERT MATERIAL; CLAY,SOIL, OR
COMMERCIALLY AVAIL ABSORBENT. SHOVEL RECLAIMED LIQ/ABSORBENT INTO
RECOVERY OR SALVAGE DRUMS FOR DISPOSAL. LG: DIKE, RECLAIM IN
DRUM,TANK,TRUCK

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMP AREAS OR
NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT IN
USEAVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME ORCUT ON EMPTY DRUMS.

Respiratory Protection:APPROPRIATE PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA) DURING & AFTER APPLICATION UNLESS AIR MONITOR DEMO
VAPOR/MIST LEVELS ARE BELOW APPLICABLE LIMITS. FOLLOW RESPIRATOR
MANUFACTURER'S DIRECTIONS FOR USE
Ventilation:SUFFICIENT VENT IN VOL/PATTERN TO KEEP AIR CONCEN BELOW
CURRENT APPL OSHA PERMISSIBLE LIMIT. REMOVE DECOMP PRODUCTS
Protective Gloves:CHEMICAL RESISTANT GLOVES
Eye Protection:CHEM GOGGLES/SAFETY GLASSES/FACE SHIELD
Other Protective Equipment:WEAR CHEMICAL RESISTANT CLOTHING AS NEEDED
TO PREVENT SKIN CONTACT. REMOVE CLOTHES THAT BECOME WET (FLAMMABLE
HAZARD)
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
RESTROOM. WASH PROMPTLY WHEN SKIN BECOMES CONTAMINATED.
Supplemental Safety and Health
CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION
TO HOT SURFACES REQUIRES SPECIAL PRECAUTIONS. DURING EMERGENCY
CONDITIONS, OVEREXP TO DECOMP PRODUCTS MAY CAUSE A HEALTH HAZAR D.
SYMPTOMS MAY NOT BE IMMEDIATELY APPA-RENT. OBTAIN MEDICAL
ATTENTION.

Boiling Pt:B.P. Text:175-302 F
Decomp Temp:Decomp Text:NE
Vapor Density:> AIR
Viscosity:75-85 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:4.56

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, NITRATES, ALKALIES, ACIDES
Stability Condition to Avoid:UNDER REASONABLE CONDITIONS OF STORAGE AND
USE
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE
Conditions to Avoid Polymerization:HIGH TEMPERATURES, SHOCK FROM
DROPPING

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.